.jpg)
⚙️ Turbocharger Iveco Daily VI 2.3L Euro 6 – Restored supercharging on F1A engine with variable geometry
🔧 What is this part for?
The turbocharger is the component responsible for increasing the amount of air admitted into the cylinders by compressing the gases at the engine intake, using the energy recovered from the exhaust gases. This supercharging improves cylinder filling, optimizes combustion, and increases available power without adding weight to the engine. On Iveco Daily VI equipped with the 2.3L F1A engine in Euro 6 version, the turbocharger is a variable geometry type (VGT) with integrated electronic actuator, allowing continuous air flow adaptation based on engine speed. A failing turbocharger results in immediate power loss, overconsumption, and can cause the vehicle to enter limp mode.
This turbocharger is supplied in new condition, without core charge. It replaces the original turbo identically on Iveco Daily VI equipped with the 2.3L F1AE3481C and F1AFL411C engine since 2014, without modification to the fuel supply circuit or the electronic actuator wiring.
✅ Technical specifications
Compatibility: Iveco Daily VI – 33S11, 35S11, 35C11 (106 hp) and 33S15, 35S15, 35C15 (146 hp) – from 03/2014
Engines: F1AE3481C / F1AFL411C – 2.3L Euro 6
Type: Variable geometry turbocharger (VGT) with electronic actuator
Turbo brand: Garrett – type GTD1749V
Condition: New, without core charge
OEM reference: IVE5801922491 / 5801922491
Garrett cross-reference: 836825-0003 / 836825-3 / 836825-5003S
Additional reference: 500061936
✅ Why replace this part?
✅ A worn or failing turbo deprives the engine of its supercharging, resulting in noticeable power loss from mid-range, black smoke on acceleration, and abnormally high diesel consumption.
✅ Excessive axial play in the center body (CHRA) causes oil leakage into the intake manifold, potentially leading to engine runaway or serious damage if not addressed.
✅ Replacement with a new turbocharger fully restores supercharging pressure, engine performance, and the reliability of the entire intake system.
✅ Symptoms of wear / failure / replacement
The most common signs of a failing turbocharger on Iveco Daily VI 2.3L Euro 6 are progressive power loss, particularly under load or when climbing, blue or black smoke from the exhaust, abnormal whistling or hissing at idle or during acceleration. An engine fault light illuminated, accompanied by entry into limp mode, is also characteristic of a VGT turbo electronic actuator fault. A check of supercharging pressure using a diagnostic tool is recommended before any replacement to confirm the source of the failure.
✅ Fitting advice
Before any work, switch off the ignition and let the engine cool completely. During removal, never grip or force the VGT turbo electronic actuator – a sensitive component whose misalignment can cause persistent dashboard faults. Drain and replace the engine oil and oil filter before commissioning the new turbo, to avoid any contamination of the new bearing. After installation, let the engine run at idle for several minutes before any load to properly prime the turbo lubrication. Check for leaks on the oil and air hoses before returning the vehicle to service. Installation by a qualified technician is strongly recommended.
✅ RAXOR Parts technical advice
When replacing the turbocharger on Iveco Daily VI 2.3L Euro 6, take the opportunity to simultaneously inspect the intercooler hoses (intake and discharge), the exhaust manifold gasket, and the turbo fixing studs – these parts are directly stressed by thermal cycles and often show advanced wear when removed. Also check the condition of the turbo oil return line, whose clogging is a frequent cause of premature failure on VGT turbos. Find all turbos and turbo parts for Iveco Daily available on RAXOR Parts for complete replacement in a single order.
✅ Why choose RAXOR Parts?
✅ New turbocharger reference IVE5801922491 / Garrett 836825-0003, specific to Iveco Daily VI 2.3L Euro 6 from 2014, direct fitting without core charge or used part return.
✅ Complementary parts available (turbo gaskets, studs, intake hoses) for complete replacement in a single order.
✅ Stock available and fast shipping to minimize your vehicle downtime.
Contact
📧 Contact us by email for any compatibility questions.
💬 Use the online chat for a quick response.
🚚 Order your Iveco Daily VI 2.3L Euro 6 turbocharger now
Place your order today on RAXOR Parts and receive your new turbocharger quickly, ready to install on your Iveco Daily.
